Valve / Product Type

Air Actuated Valve

air actuated valves that utilise a compressed air supply to operate.

Air Filters Regulators & Oilers

Air pressure regulator with air filter with air lubrication system. Provides stable outlet pressure whilst removing debris and 90% moisture the finally providing oil mist to lubricate downstream equipment.

AirLine Fittings + Tube

compressed air line tubing and push to connect fittings

Check Valve

Check + non return valves only allow flow in one direction

Filters

Filters designed to remove particulate or debris from gases or fluids.

Manual + Mechanical Control

Air valves that are controlled manually and mechanically

Pressure Reducing

Pressure reducing valves (PRV) reduce and maintain stable outlet pressure

Pressure Relief

Safety pressure relief / pressure limiting valve (PLV), stays closed until pressure reaches set pressure - then quickly opens, releasing any excess pressure.

Pressure Sustaining

Pressure sustaining / back pressure valve, maintains a minimum preset upstream (Inlet) pressure, valve will close if pressure drops to set pressure and reopens when inlet pressure increases again.

Quick Exhaust

Will instantly open outlet to exhaust when the inlet pressure drops to greatly increase cylinder reaction speed.

Safety Shut Off

Safety shut off isolation valve, shuts off and secures air line systems, will vent downstream air when closed.

Shuttle Valve

Incorporates a check ball valve to allow pressure in a line to be obtained from two sources.

Soft Start

Electric open and close control for airline systems, power off downstream air is vented to atmosphere - power on opens slowly to prevent sudden pressure surges.

Solenoid Valve

Valves controlled by electrical signal via a solenoid or electro magnet.

Vacuum breaker/ Air release

valves that release trapped air and vacuum

Vacuum Generator

Vacuum generators utilise compressed air (1 to 6 Bar) to generate vacuum to -91.8 Kpa, sizes 1/8, 1/4 or 3/8.

Push In Elbow / Banjo

Male and female BSP and metric pneumatic push to connect elbow fittings

Push In Flow & Speed Control

Push fittings with flow or speed control for compressed airlines

Push In Plugs/ Caps + Reducers

Push in blank Caps/ Plugs and reducing fittings

Push In Unions

Male and female BSP and metric union pneumatic push to connect fittings

Port Size

Media

Body Material

Function

2/2 Normally Closed

2 ports (inlet/outlet) with 2 positions (Open/Closed) - valve stays closed (Failsafe) requires power to open

2/2 Normally Open

2 ports (inlet/outlet) with 2 positions (Open/Closed) - valve stays open (Failsafe) requires power to close

3/2 Normally Closed

3 ports with 2 positions. Power off inlet closed, outlet open to exhaust - power on inlet open to outlet with exhaust closed.

3/2 Normally Open

3 ports 2 positions. Inlet open to outlet with exhaust closed - power on inlet closed with outlet open to exhaust.

5/2 Single Acting

5 ports 2 positions (1 inlet, 2 outlets, 2 exhaust ports). Power to coil Cylinder fully extends - Power off cylinder fully retracts (or visa versa)

5/2 Double Acting

Power to left coil Cylinder fully extends, power to right coil cylinder fully retracts, power off cylinder stays put fully extended or retracted.

5/3 Way

Power to left coil cylinder extends, power to right coil cylinder retracts, power off cylinder stays put even in a mid position.

Pressure

Seals

NBR

NBR (Nitrile Buna Rubber) known as Nitrile Butadine, Buna-N, Hycar, Chemigum, Butakon, Breaon, Butacril, Paracil, Nipol, Perbunan, Krynac or Europrene-N. Good for Aliphatic Hydrocarbons, Petroleum, Fuels, Mineral Oil, Vegetable and Hydraulic Oil, Alcohol and many Acids. -35°C to +100°C. Poor for Ozone, Acetone, Methyl ethyl Ketone, Chlorinated Hydrocarbons, Ethers and Esters.

PTFE (Teflon)

PTFE (Polytetrafluoroethylene) also known as Teflon® Dupont registered. Excellent resistance to almost every fluid or gas. -200°C to +230°C

Voltage

Approval: ATEX,WRAS,IP etc

ATEX Exm

ATEX Protection by encapsulation ll 2 G Ex mb ll T4 Gb and ll 2 D Ex tb IIIC T130°C Db IP65

IP65

Dust tight and protected against water jets

Orifice

Operation

Direct Acting

Directly controls flow without external pressure assistance operates from vacuum upwards.

Pressure Assisted

Operate via pilot pressure control and require a minimum pressure difference between inlet and outlet from 0.5 Bar.

Options required

Spares (Coils, Connectors, Seals)

Only Show Items In Stock

Hide spare parts

Other Air valves + accessories

Filters

1318 IN STOCK

175 IN STOCK

556 IN STOCK

72 IN STOCK

267 IN STOCK

204 IN STOCK

68 IN STOCK

634 IN STOCK

29 IN STOCK

106 IN STOCK

48 IN STOCK

71 IN STOCK

107 IN STOCK

147 IN STOCK

83 IN STOCK

127 IN STOCK

6 IN STOCK

11 IN STOCK

116 IN STOCK

13 IN STOCK